Trojan Battery Company 24 AES
SKU 24AES
Trojan Battery Companytrojanbattery.com/products/24-aes-12v-aes-battery
The Trojan Battery Company 24 AES is a battery pack with a nominal capacity of 76 Ah at the 20-hour rate, 1.01 kWh of energy and 1,200 cycles.
Last updated: 1 November 2026
Battery and charging
- Reserve minutes, at a stated current
- 137 minutes at 25 amps
- Battery weight
- 54 (25)
- Rated charge cycles
- 1,200 cycles at 100% DoD
- Nominal capacity
- 76 Ah at the 20-hour rate
- Capacity, at the 20-hour rate
- 76
- Capacity, at the 5-hour rate
- 67
- Capacity, at the 10-hour rate
- 70
- Reserve capacity
- 137
- Stated energy
- 1.01 kWh
“BAttery Quick Facts Capacity Minutes @25 Amps / 137 Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah Energy (kWh) 1.01 Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219) Weight lbs. (kg) 54 (25) Operating Temperature -40°F to 140°F (-40°C to 60°C)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Weight lbs. (kg) 54 (25) Operating Temperature -40°F to 140°F (-40°C to 60°C)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Up to 3x longer cycle life than standard AGM batteries. Validated at 1,200 cycles at 100% DoD vs. 400 cycles for AGM.”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“BAttery Quick Facts Capacity Minutes @25 Amps / 137 Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah Energy (kWh) 1.01 Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219) Weight lbs. (kg) 54 (25) Operating Temperature -40°F to 140°F (-40°C to 60°C)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Capacity Minutes @25 Amps / 137”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“BAttery Quick Facts Capacity Minutes @25 Amps / 137 Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah Energy (kWh) 1.01 Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219) Weight lbs. (kg) 54 (25) Operating Temperature -40°F to 140°F (-40°C to 60°C)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
Battery care and safety
- Operating temperature range
- -40°F to 140°F (-40°C to 60°C)
“Operating Temperature -40°F to 140°F (-40°C to 60°C)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
Size and fit
- Length
- 274 mm
- Width
- 174 mm
- Height
- 219 mm
- Terminals
- Automotive Post & Stud Terminal DT
- Stated weight
- 54 lbs, as the quick facts panel states it
“Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“TERMINAL TYPES Automotive Post & Stud Terminal DT”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
“BAttery Quick Facts Capacity Minutes @25 Amps / 137 Capacity Amp-Hours 5-Hr Rate / 67 Ah 10-Hr Rate / 70 Ah 20-Hr Rate / 76 Ah 100-Hr Rate / 84 Ah Energy (kWh) 1.01 Dimensions inches (mm) Length / 10.77 (274) Width / 6.84 (174) Height / 8.62 (219) Weight lbs. (kg) 54 (25) Operating Temperature -40°F to 140°F (-40°C to 60°C)”
Source: trojanbattery.com/products/24-aes-12v-aes-battery
Devices whose figures this pack does not meet
Neither maker names the other. These devices publish a draw this pack’s own maker does not rate it to deliver continuously. That is a comparison of two documents and not a manufacturer’s refusal — check both against your own equipment before deciding anything.
Minn Kota's manual for this motor asks for at least a 105 amp-hour rating and says the motor will run on any lead-acid, deep-cycle marine 12-volt battery.
Minn Kota do not say which discharge rate their figure applies to, and Trojan publish four figures for this battery: 67 at the 5-hour rate, 70 at 10, 76 at 20 and 84 at 100.
The 20-hour rate is the conventional marine rating and the one compared.
Minn Kota's website battery guide asks for 110 amp-hours rather than the manual's 105, and they have not reconciled the two; at 76 this battery falls short of both.
Neither company has named the other and nobody has tested the pairing.
Trojan rate the 24 AES at 76 amp-hours at the 20-hour rate each, 29 amp-hours short of it.
Their amp-hour figure is asked of the battery rather than of the string, so it is compared against a single one.
- Minn Kota Terrova 55 lb (54" shaft, wireless remote)Figures compared — they do not meetView device: Minn Kota Terrova 55 lb (54" shaft, wireless remote) →
Trojan rate the 24 AES at 76 amp-hours at the 20-hour rate, 29 amp-hours short of it. Trojan give 137 minutes of reserve at 25 amps, well below the 50 amps Minn Kota state as this motor's maximum draw, and publish nothing at a higher current. Minn Kota's battery-guidance table recommends AGM or lithium at 100 amp-hours for a 55 lb motor, alongside the manual sentence quoted above.
- Minn Kota Terrova 80 lb (60" shaft, wireless remote)Figures compared — they do not meetView device: Minn Kota Terrova 80 lb (60" shaft, wireless remote) →
Trojan give 137 minutes of reserve at 25 amps, well below the 56 amps Minn Kota state as this motor's maximum draw, and publish nothing at a higher current. Minn Kota's manual for this motor is explicit that two 12-volt batteries wired in series are required. Their battery-guidance table recommends lithium at 100 to 125 amp-hours for an 80 lb motor, which is a different chemistry from this one — the manual and the table are both Minn Kota's and they do not agree.
- Minn Kota Terrova 112 lb (60" shaft, CHIRP sonar, wireless remote)Figures compared — they do not meetView device: Minn Kota Terrova 112 lb (60" shaft, CHIRP sonar, wireless remote) →
Trojan give 137 minutes of reserve at 25 amps, well below the 52 amps Minn Kota state as this motor's maximum draw, and publish nothing at a higher current. Minn Kota's manual for this motor is explicit that three 12-volt batteries wired in series are required. Their battery-guidance table recommends lithium at 125 to 150 amp-hours for a 112 lb motor, which is a different chemistry from this one — the manual and the table are both Minn Kota's and they do not agree.
Do not charge with
The manufacturer states these chargers must not be used with this battery:
- PD4500LI Series Power Control CenterStated incompatibleView charger: PD4500LI Series Power Control Center →
Progressive Dynamics state it outright about this converter: "The 4500LI series converter/chargers are designed to recharge lithium iron phosphate (LiFePO4) batteries only. DO NOT USE TO RECHARGE LEAD/ACID BATTERIES!" This pack is AGM, which is a lead-acid chemistry, so their sentence covers it. They say nothing about packs of other chemistries and nothing here extends it past what it covers.
Source: forestriverinc.com/files/component-manuals/Electrical/Progressive Dynamics - Power Converter Model PD4500 Series Operation Guide.pdf
Sources
- Trojan 24 AESManufacturer model page
Source: trojanbattery.com/products/24-aes-12v-aes-battery
Retrieved September 16, 2026
- Progressive Dynamics PD4500 Series Operation GuideManufacturer document
Progressive Dynamics
Source: forestriverinc.com/files/component-manuals/Electrical/Progressive Dynamics - Power Converter Model PD4500 Series Operation Guide.pdf
Retrieved September 20, 2026